Abstract
Rice production helps feed at least half of the world’s population but generates approximately one billion tonnes of straw residue per annum. On-site open burning of rice straw after harvesting is common in recent times because there has been less demand for rice straw to use as fuel and fodder. Due to health and climate change concerns, open burning, which results in biomass losses, smog and emissions of green house gases, e.g., CO2, has been widely criticized and banned in many countries. Little is known about the positive benefits of straw burning, such as field care (eradication of biotic diseases) or nutrient cycling. Herein, we propose a new viewpoint in which the burning of rice straw followed by cycling of the burned materials, including silica material (so-called phytolith), into soil is demonstrated as a CO2-sequestration strategy via buffering the soil CO2 flux and coupling CO2 with the silicon cycle.
Similar content being viewed by others
Introduction
Rice straw burning has been widely judged as an environmental concern contributing to global CO2 and black carbon emissions1. Many regions or countries, e.g., the US, EU, China, India, Australia and Southeast Asia, have banned straw burning, although these bans were likely based on a singular view that is still under debate2,3,4. Even so, immediate cessation of on-site burning worldwide is implausible because there is lack of consensus in many rice-based countries, where the governments cannot involve farmers in alternative practices that are more effective3. This outcome suggests that such bans need stronger evidence or incentives to cause farmers to change their method of handling straw. Any incentives towards reducing or stopping on-site burns will likely reshape the method of managing straw, affecting hundreds of millions of farmers worldwide. Currently, the best method is unknown because straw burning is not simply an environmental treatment. We also have to address other relevant issues, such as agronomic re-practicing, soil degradation, disease outbreaks and the increasing accumulation of arsenic in rice. These issues indicate that a multi-dimensional approach or integrated solution is crucial for solving straw burning issues and that a balance between “gains and losses” needs to be strictly taken into account.
Mitigation of CO2 emissions is a common reason for bans; however, this adjudication is placed in a relatively narrow context – “straw biomass loss from burning”, and the effect of the burning process on the whole CO2 cycle of the paddy rice system is neglected. Recent studies have revealed that burning removes straw organic carbon (OC) but also releases burned matter (alkaline elements and fast-reacting silica) that have been reported to increase CO2 sequestration and reduce CO2 emissions from soil5,6. In addition, straw biomass is routinely believed to be fully decomposed in open burning, while the effect of other inter-embedded matter, e.g., phytolith, is ignored. Many recent works have demonstrated the phytolith structure is a carrier that sequesters straw OC7,8,9, and some studies have reported the possible ability of phytoliths to act as a shield to slow down the thermal decomposition of OC10,11. Obviously, this result encourages further work on how and to what extent phytoliths can preserve straw OC under open burning. Our research with a central focus on CO2 and phytolith interactions was to demonstrate the contrasting scenarios of burning rice straw and CO2 emission/sequestration and to show the need to review both the negative and positive aspects of the straw open burning before enforcing hard bans.
Results
Straw phytolith captures organic carbon
Phytolith is a silica structure that is commonly observed in silicon (Si)-rich plant species, e.g., grass, bamboo, ferns, wheat and especially rice12. Tomographic observations of rice straw have illuminated a phytolith structure and its subcompartmentation of OC (Fig. 1A–C). Within the bundle sheath and the leaf surface, tightly packed bundle-sheath cells and more loosely arranged mesophyll cells are held by silicified structures in inter- and intra-cellular spaces. Condensation of the silica phase in the leaf part is most likely due to the abundance of Si input supplied from transport sap and a high evaporation rate13,14. Forming inside organic tissues, phytolith is fed by the polymerization of Si, leading to an expansion of its legacy and eventually occlusion of OC in its structure. As a result, OC is involved in the fate of phytoliths. When plant residues are cycled into soil, phytolith-occluded OC (phytOC) can also be cycled and accumulated in soil. This phytOC is preserved by the phytolith structure and is secure from biodegradation.
To date, the occlusion of OC within the phytolith structure has been examined in many studies7,8,15. A recent high-end technique, i.e., X-ray microtomography, allows visualization inside the tissue organs of straw and provides a better understanding of how the silica phytolith skeleton can protect the OC occluded inside its structure (Fig. 1C). The association of phytolith silica and occluded OC can be physically and chemically strengthened. Condensation of phytolith silica via precipitation of Si from transport sap is a process that can consolidate the physical association between the phytolith and cuticle at the outer tangential epidermis cell wall16. Chemical bonds such as Si−C and Si−OR form on the tissue cell walls as a result of the priming effects of the chemical association followed by dehydration of silica and organic carbon17. This physico-chemical reaction chain strengthens the occlusion of OC within the phytolith structure.
Thermal resistance of phytolith-associated organic carbon
In rice paddy systems, open burning rather than incorporation is the preferential practice, and this process can alter both phytoliths and their occluded OC18,19. Phytoliths will be reshaped because silica is subject to condensation to form more stable phases, e.g., cristobalite or tridymite20, whereas OC will be transformed eventually into carbon gases, e.g., CO2, CO, C1−C2 hydrocarbons and other volatile substances21. Figure 2A clearly shows the weight loss along with the decrease in the OC content. While open burning at approximately 420 °C resulted in a loss of half the OC, temperatures at >400 °C (in controlled pyrolysis experiments) led to more extensive loss of OC. The outer OC (outside the phytolith structure), which is directly subjected to fire or high temperatures, will be removed first. The inner OC (here phytOC) might be decomposed at lower rates, and the extent to which phytOC is lost by thermal decomposition is likely related to the strength of its association with the phytolith structure. If it is protected by the phytolith structure, where limited oxygen can penetrate, phytOC is believed to be more recalcitrant to thermal decomposition, and consequently black carbon can be formed to a given extent. The dark parts inside straw ash from open burning (easily observable by naked eyes) might be related to the black carbon derived from the internal anaerobic conditions of the ash phytolith structure. In ash phytoliths, black carbon is commonly observed in association with the silica phytolith structure (Fig. 2B,C). The black carbon or internal OC part is protected by the associating phytolith and stabilised by forming Si−C and Si−OR bonds with phytolith silica (as deduced from XPS analyses in Fig. 2D).
Straw-derived phytoliths are involved in buffering soil CO2 fluxes
Phytolith makes up from 1.6 to 14.4% of rice (stem, sheath, and leaf)9,22, thereby hundreds of million tonnes of phytolith are recycled annually if all world rice residues are returned to the soil instead of exported or used for other purposes. Phytoliths, including fresh phytolith (from straw residue incorporated into soil), ash phytolith (obtained from straw burning) and aged phytoliths (both fresh and ash phytoliths buried in soil), might co-exist in rice field. Because CO2 fluxes (as high as 8.62 µmol m−2 s−1 23) originate from the aerobic decomposition of soil OC (e.g., in root zone) and can diffuse extensively over a rice field, it is likely that CO2 fluxes penetrate water and contact phytoliths, by which they are then transformed in different ways, as schematically described in Fig. 3.
The solubility of CO2 is highly pH dependent, and the soluble forms of CO2 include H2CO3, HCO3− and CO32−. Therefore, the straw cycle and its derived phytoliths in the soil can change the soil pH and drive the CO2 buffer capacity. Incorporation of straw into soil has been encouraged24, but it creates a more acidic environment because straw serves as organic matter for decomposition to form organic acids25. Hence, this practice, as a result, decreases the CO2 buffer capacity and favours CO2 emission (reaction #1). In contrast, open burning removes organic matter (transformed to gases) and produces highly alkaline materials with typical pH values ranging from 10 to 1113. Burning and returning burned products (ashes) can generally increase the soil pH, leading to higher solubility of CO2. Ashes contain not only immediately available alkali ions (Supplementary Table S1) but also phytolith-occluded alkali ions13. Considering these outer and inner alkali ion sources, the effect of burned materials in buffering the soil CO2 flux can be divided into two stages involving the direct release of outer alkali ions and the “slow release” of phytolith-occluded alkali ions (reaction #2). In an experiment to simulate the release of potassium (K) accompanying the dissolution of phytoliths, Nguyen, et al.20 demonstrated a mechanism in which the K located in the phytolith structure is slowly released when the phytoliths are destroyed. This result implies that ash phytoliths can increase the soil pH and buffer CO2 flux via releasing and providing their internal alkali elements. Dissolution of silicate minerals has been known as a natural process that captures CO26. This CO2 capture can be magnified for fast-reacting silicate rocks (e.g., basalt)5,26. Likewise, phytolith silica, which is a highly soluble material13, is also expected to react in the same way to mitigate CO2 emission. Because the dissolution rate of phytoliths is controlled by various physico-chemical properties of soil solutions, e.g., pH and ionic strength13, the fate of phytoliths and their role in mitigating CO2 emissions are, therefore, expected to vary from one soil/region to another.
The second CO2 sequestration mechanism (reaction #3) relates to electro-chemical interactions between CO2 and phytolith surfaces (Fig. 4A). Our parallel system to measure CO2 adsorption and the electro-kinetics of phytolith suspensions (Fig. 4B) revealed the ability of phytoliths to capture CO2 (Fig. 4C) (Supplementary Table S2) and the electro-chemical process that governs CO2 sequestration (Fig. 4D). In a suspension, the phytolith surface develops a net negative charge primarily due to deprotonation of the surface Si−OH groups, and this process steadily increases in the pH range from 2 to 10 or even higher13,27. Reversibly, protonation of the negative phytolith surface might occur, and this process is likely a highly rapid, exothermic reaction with no significant activation energy that occurs via the concerted motion of the protons along a chain of water molecules27. Because H2CO3 acid has a pKa1 of 6.4, we can expect phytoliths with their alkaline nature to facilitate the deprotonation of H2CO3 and attract free H+ ions for transfer to their surface, by which phytoliths facilitate CO2 conversion into HCO3− or even CO32− and prevent reversion of CO32− or HCO3− back to CO2. In our short-run experiments, the protonation due to the increasing presence of CO2 in suspensions resulted in gradual decreases in the pH and increases in zeta potential (ζ) (Fig. 4D) (Supplementary Table S3). Differences in the variation ranges of pH and ζ between the open burning and controlled heating samples were likely because of their charge densities28. The CO2 amounts that reacted with the phytolith suspensions were calculated to be ~30g CO2 kg−1 for the open burning sample and from ~15 to 40g CO2 kg−1 for the controlled heating samples.
Discussion
The findings on the positive aspects of on-site burning with the central role of phytoliths suggest a need for multi-dimensional views to mediate the debates and encourage new strategies. By bringing CO2 emission from on-site straw burning and CO2 sequestration in soils driven by straw-derived phytoliths together, a more detailed picture of the gains and losses from open burning was revealed. Straw open burning results in direct CO2 emission; however, the burned products remaining in a field can be involved in processes that enable CO2 sequestration via conversion of CO2 into HCO3− or CO32− in the presence of phytoliths. This conversion might be related to various processes, such as the dissolution of straw ash phytoliths to release alkali elements, the reaction of released alkali elements and dissolved CO2 to form HCO3−, and protonation of the negatively charged surface of phytoliths that can convert H2CO3 into HCO3−. All these processes occur concurrently and interactively; however, our study still cannot determine the order, rate and preference of each individual process.
In addition, it was evidenced that the phytolith skeleton can also protect its occluded OC by favouring an “internal anaerobic” condition, which prohibits oxidation of OC and reduces CO2 emission from open burning. This result suggests that developments in burning techniques considering electro-chemical changes can both preserve straw OC and produce materials to enhance soil CO2 sequestration. Overall, as straw management might involve billion tonnes of CO2 annually released or sequestered worldwide, it is urgent to re-evaluate straw burning on the field scale at which elemental cycles can be entirely closed and other benefits from burning rice straw can also be assessed. More extensive and intensive discussion is necessary. Biomass loss and air pollution are the major reasons for exporting straw, and not returning straw’s occluded nutrients to a field need to be re-considered. Straw ash phytoliths should be given a chance to demonstrate their potential to mitigate soil CO2 emissions.
Our short-run experiments indicated possible reactions that sequester CO2 in phytolith suspensions; however, these experiments cannot simulate or generalize the effect of phytoliths on CO2 emissions on field, regional or larger scales, where many challenges will be raised. The heterogeneous dissolution of phytoliths due to their complicated chemical composition is one of the most difficult obstacles, and many attempts are still being made to elucidate the ageing of phytoliths and the subsequent changes in their surface properties. Under field conditions, soil biological processes, e.g., decomposition, mineralization, and respiration, which may vary from one region to another, will likely alter phytoliths and their surface reactions to sequester CO2 at different levels. Therefore, the inclusion of such individual experiments from various ecoregions or biomes will allow the creation of larger and more realistic databases for the calculation of CO2 sequestration. Last, many current cultivation initiatives regarding fertilization, irrigation, puddling, and weeding have been strategically moved towards decreasing CH4 emissions or limiting arsenic accumulation in rice, and from now, in addition to CH4 and arsenic issues, it is also worth incentivizing methods that can activate phytoliths to sequester more CO2. If all these challenges are solved, adjustment of the contributions or effects of straw phytoliths to the global CO2 cycle can be made.
Materials and Methods
Sample preparation
Straw samples were collected at harvest time in a central part of the Red River Delta, Vietnam. Samples were air dried, oven dried at 70 °C, and then finely chopped into ~1 mm segments prior to analysis. Open burning of each 500 g of straw was performed in open-air conditions, and it took approximately 20 min for the straw samples to be burned completely. The burning temperatures, which were measured by directly injecting a thermo probe (330-1 LL, Testo) into the straw piles, were averaged to be ca. 420 °C. Because burning is exothermic depending upon the ambient air condition (e.g., wind velocity, humidity) and the manner of burning (scatter or pile up), we also treated straw samples in controlled pyrolysis conditions to evaluate the chemical composition and surface properties of the obtained straw phytoliths over a wider temperature range. The pyrolysis process was set up at a heating rate of 10 °C min−1 and maintained at the target temperatures (from 250 to 950 °C with intervals of 50 °C) for 1 h. The samples obtained from open-burning and controlled pyrolysis conditions were ball milled and passed through a 0.25 mm sieve.
Sample characterization
The chemical composition of the straw and ashes obtained from open-burning and controlled heating experiments was examined by the PIXE (particle induced X-ray emission) method, using the proton beam of the Tandem accelerator (5SDH-2 Pelletron accelerator system, manufactured by National Electrostatics Corporation, USA) (Supplementary Table S4). The OC content in the phytoliths was determined using the classical wet digestion method with concentrated H2SO4 and 133 mol L−1 K2Cr2O7 at 170–180 °C29. Thermogravimetric analysis (TGA) was conducted for straw samples using a Macro-TGA device designed by CIRAD. Specific surface area (SSA) was measured using a Gemini VII 2390p surface area analyser. Soluble ions dissolved from open-burning or controlled heating ashes were analysed by using inductively coupled plasma mass spectrometry (ICP-MS 7900, Agilent Technologies). The accuracy was assessed using the European Commission’s standard reference materials BCR-277R. Recovery rates of the elements ranged from 90% to 110% (Supplementary Table S1).
The straw sample was scanned by ZEISS Xradia 520 Versa 3D X-ray microscope at the University of Kassel. The 3D X-ray microscope enables visualization of the silica phytolith structure and organic matter phase in rice leaves. The 3D phytolith and organic matter structures were assembled from 975 individual 2D image slices with 995 × 972 isotropic pixels (the pixel size was 1.14 µm) using the open-source software YaDiV30. The 256 grey values depict element densities: air has grey values < 50), the OC phase coloured in green has grey values from 50 to 200, and the high-density phase, i.e., phytolith, coloured in violet has grey values of approximately >200. X-ray photoelectron spectroscopy (XPS) is a particular surface-sensitive analysis technique, and the XPS-based data can be expected to visualize the integration between organic matter and inorganic phases (e.g., phytolith). The open-burning ash sample was analysed by XPS using an AXIS-NOVA spectrometer (SHIMADZU/KRATOS, Japan) with monochromatic AlKa radiation (15 kV 10 mA).
Electrokinetics of phytoliths and CO2 sequestration
The parallel and connected systems assembled to monitor the electrokinetics of phytoliths and CO2 sequestration are illustrated in Fig. 4B. CO2 gas was supplied at the rate of 0.1 L min−1 into two parallel reactors for (1) monitoring ζ changes and (2) measuring reacted CO2 (adsorbed) at the same time. In the first block, ash phytolith suspensions (50 mg in 20 mL deionized water) were transferred into a reaction Teflon cup in the PCD-based system with a particle charge detector (PCD 05, Muetek), and the supply of CO2 was halted when the pH stopped decreasing. Changes in pH and ζ were recorded every 10 s, and the experiments were terminated when the pH stopped decreasing. In the second block, CO2 was consumed (adsorbed) in 20 mL of a 0.005 N NaOH solution, which represents CO2 reacting with phytolith suspensions (in the first block), and titrated with 0.005 N H2SO4 solution. All measurements were conducted in triplicate. NaOH and H2SO4 were purchased from Merck, while CO2 (99.99%) was provided by Ha Bac Nitrogenous Fertilizer and Chemical Ltd. Company.
References
Gustafsson, Ö. et al. Brown Clouds over South Asia: Biomass or Fossil Fuel Combustion? Science 323, 495–498 (2009).
Tore, A. Thinking Glocal to solve India’s paddy-straw burning crisis. Agriculture News in Down To Earth (2019).
Pandey, P., Valkenburg, G., Mamidipudi, A. & Bijker, W. E. The key to resolving straw burning: farmers’ expertise. Policy brief on missing cultural perspectives. Maastricht, the Netherlands: Maastricht University (2017).
Vagg, A. Rice straw utilisation - Value adding and alternative uses for the Australian rice industry. In “A report for Nuffield Australia farming scholars”. Nuffield Australia (2015).
Beerling, D. J. et al. Farming with crops and rocks to address global climate, food and soil security. Nature Plants 4, 138–147 (2018).
Sommer, M., Kaczorek, D., Kuzyakov, Y. & Breuer, J. Silicon pools and fluxes in soils and landscapes - a review. J. Plant Nutr. Soil Sci. 169, 310–329 (2006).
Song, Z., McGrouther, K. & Wang, H. Occurrence, turnover and carbon sequestration potential of phytoliths in terrestrial ecosystems. Earth-Science Rev. 158, 19–30 (2016).
Parr, J. F. & Sullivan, L. A. Soil carbon sequestration in phytoliths. Soil Biol. Biochem. 37, 117–124 (2005).
Li, Z., Song, Z., Parr, J. F. & Wang, H. Occluded C in rice phytoliths: implications to biogeochemical carbon sequestration. Plant Soil 370, 615–623 (2013).
Xiao, X., Chen, B., Chen, Z., Zhu, L. & Schnoor, J. L. Insight into multiple and multilevel structures of biochars and their potential environmental applications: A critical review. Environ. Sci. Technol. 52, 5027–5047 (2018).
Nguyen, M. N. et al. Fern, Dicranopteris linearis, derived phytoliths in soil: Morphotypes, solubility and content in relation to soil properties. Eur. J. Soil Sci. 70, 507–517 (2019).
Sharma, R., Kumar, V. & Kumar, R. Distribution of phytoliths in plants: a review. Geology, Ecology, and Landscapes 3, 123–148 (2019).
Nguyen, N. M., Dultz, S. & Guggenberger, G. Effects of pretreatment and solution chemistry on solubility of rice-straw phytoliths. J. Plant Nutr. Soil Sci. 177, 349–359 (2014).
Meunier, J. D. et al. Effect of phytoliths for mitigating water stress in durum wheat. New Phytol. 215, 229–239 (2017).
Sun, X. et al. Comparison of phytolith-occluded carbon in 51 main cultivated rice (Oryzasativa) cultivars of China. RSC Advances 7, 54726–54733 (2017).
Nguyen, H. X. et al. Characterization and implication of phytolith-associated potassium in rice straw and paddy soils. Arch. Agron. Soil Sci. 65(10), 1354–1369 (2018).
Han, L. et al. Oxidation resistance of biochars as a function of feedstock and pyrolysis condition. Sci. Total Environ. 616-617, 335–344 (2018).
Tran, C. T. et al. Phytolith‐associated potassium in fern: characterization, dissolution properties and implications for slash‐and‐burn agriculture. Soil Use and Management 34, 28–36 (2018).
Trinh, T. K. et al. Characterization and dissolution properties of phytolith occluded phosphorus in rice straw. Soil Till. Res. 171, 19–24 (2017).
Nguyen, N. M. et al. Release of potassium accompanying the dissolution of rice straw phytolith. Chemosphere 119, 371–376 (2015).
Yang, H., Yan, R., Chen, H., Lee, D. H. & Zheng, C. Characteristics of hemicellulose, cellulose and lignin pyrolysis. Fuel 86, 1781–1788 (2007).
Prajapati, K. Carbon occlusion potential of rice phytoliths: Implications for global carbon cycle and climate change mitigation. Appl. Ecol. Env. Res. 14, 265–281 (2016).
Liu, Y. et al. Carbon dioxide flux from rice paddy soils in central China: Effects of intermittent flooding and draining cycles. Plos One 8, e56562 (2013).
Blank, S. C., Jetter, K. M., Wick, C. M. & Williams, J. F. With a ban on burning, incorporating rice straw into soil may become disposal option for growers. California Agriculture 47, 8–12 (1993).
Shan, Y., Cai, Z., Han, Y., Johnson, S. E. & Buresh, R. J. Organic acid accumulation under flooded soil conditions in relation to the incorporation of wheat and rice straws with different C:N ratios. Soil Sci. Plant Nutr. 54, 46–56 (2008).
Blencoe, J. G., Palmer, D. A., Anovitz, L. M. & Beard, J. S. Carbonation of metal silicates for long-term CO2 sequestration. US patent (2014).
Lowe, B. M., Skylaris, C.-K. & Green, N. G. Acid-base dissociation mechanisms and energetics at the silica–water interface: An activationless process. J. Colloid Interface Sci. 451, 231–244 (2015).
Mai, N. T. et al. Fern Dicranopteris linearis-derived biochars: Adjusting surface properties by direct processing of the silica phase. Colloid Surface A, 123937 (2019).
Li, Z., Song, Z. & Li, B. The production and accumulation of phytolith-occluded carbon in Baiyangdian reed wetland of China. Appl. Geochem. 37, 117–124 (2013).
Friese, K. I., Cichy, S. B., Wolters, F. E. & Botcharnikov, R. E. Analysis of tomographic mineralogical data using YaDiV–Overview and practical case study. Comp. Geosci. 56, 92–103 (2013).
Acknowledgements
X-ray-tomographic microscopy was performed with the skilful help of Julie Fife at the University of Kassel. The authors would like to thank Sarah B. Cichy at the GFZ German Research Centre for Geosciences, Potsdam and Stefan Dultz at the Institute of Soil Science, Leibniz University Hannover for help with the morphological characterization of the phytoliths from the tomographic dataset. X-ray photoelectron spectroscopy was performed at the Kyushu Institute of Technology, and we gratefully acknowledge Dr. Toshiki Tsubota for his support. We thank Dr. Nam H. Nguyen at the University of Science and Technology of Hanoi (USTH) for TGA analysis. We express our gratitude to the PIXE team at the Faculty of Physics, the Soil-Lab team at the Faculty of Environmental Science, Vietnam National University (VNU) for their technical support.
Author information
Authors and Affiliations
Contributions
M.N.N designed the study and wrote the paper. A.T.Q.N. performed the model experiments and analysis.
Corresponding author
Ethics declarations
Competing interests
The authors declare no competing interests.
Additional information
Publisher’s note Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary information
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The images or other third party material in this article are included in the article’s Creative Commons license, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons license and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this license, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Nguyen, A.T.Q., Nguyen, M.N. Straw phytolith for less hazardous open burning of paddy straw. Sci Rep 9, 20043 (2019). https://doi.org/10.1038/s41598-019-56735-x
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/s41598-019-56735-x
This article is cited by
-
2000 Year-old Bogong moth (Agrotis infusa) Aboriginal food remains, Australia
Scientific Reports (2020)
Comments
By submitting a comment you agree to abide by our Terms and Community Guidelines. If you find something abusive or that does not comply with our terms or guidelines please flag it as inappropriate.